A Clunky, Reusable Mask May be the Answer to N95 Waste – The New York Times

A Clunky, Reusable Mask May be the Answer to N95 Waste – The New York Times

Experts say the U. S. government has unintentionally encouraged a dependency on imported masks by failing to promote elastomeric respirators, a reusable mask that is domestically produced.

In the early 1990s, long before P. P. E., N95 and asymptomatic transmission became household terms, federal health officials issued guidelines for how medical workers should protect themselves from tuberculosis during a resurgence of the highly infectious respiratory disease.

Their recommendation, elastomeric respirators , an industrial-grade face mask familiar to car painters and construction workers, would in the decades that followed become the gold standard for infection-control specialists focused on the dangers of airborne pathogens.

The Centers for Disease Control and Prevention promoted them during the SARS outbreak of 2003 and the swine flu pandemic of 2009. A few studies since then have suggested that reusable elastomeric respirators should be essential gear for frontline medical workers during a respiratory pandemic, which experts predicted would quickly deplete supplies of N95s, the disposable filtration masks largely made in China.

But when the coronavirus swept the globe and China cut off exports of N95s, elastomeric respirators were nowhere to be found in a vast majority of hospitals plus health clinics in the United States. Although impossible to know for sure, some experts believe the dire mask shortage early on contributed to the wave of infections that killed more than 3, 600 health workers.

The particular pandemic has generated a bevy of painful lessons about the importance of preparing for public health emergencies. From the Trump administration’s tepid early response to the C. D. C. ’s bungled coronavirus testing rollout and its mixed messaging on masking, quarantining and the reopening of schools, the federal government has been roundly criticized for mishandling a health crisis that has left one million Americans dead and dented public faith in an once-hallowed institution.

Three years into the pandemic, elastomeric respirators remain a rarity at American health care facilities. The C. D. C. has done little to promote the face masks, and all but a handful of the particular dozen or so domestic companies that rushed to manufacture them over the past two years have stopped making the goggles or have folded because demand never took off.

Most cost between $15 and $40 each, as well as the filters, which should be replaced at least once a year, run about $5 each. Made of soft silicone, the masks are comfortable to wear, according to health care worker surveys, and they have a shelf life of a decade or more.

“It’s frustrating and frightening because a mask like this can make the difference between existence and death, but no one knows about them, ” said Claudio Dente, whose company, Dentec Safety, recently stopped making elastomeric respirators that were specifically redesigned at the request of federal regulators with regard to health care workers.

The government’s tentative approach to elastomeric respirators during the pandemic has largely escaped public scrutiny, even as American mask producers, health policy experts and nursing unions have been pressing federal officials to promote them more aggressively. The masks, they note, are an environmentally sustainable and cost-effective alternative to N95s. Worn properly, they offer better protection than N95s, which usually, as their name suggests, only filter out 95 percent associated with pathogens. Most elastomerics exceed 99 percent.

The masks have another notable attribute: Most are made in the United States.

Chinatopix, via Associated Press

Now that hospitals have resumed buying cheap, Chinese-made face coverings and the resurgent American mask industry has imploded, experts warn of the perils of the nation’s continued dependency on foreign-made protective equipment. Many of the U. S. companies calling it quits are start-ups whose founders jumped into the P. P. E. business out of a sense of civic duty.

“It’s sad to see all of this manufacturing capacity come online during a crisis, only to be shut down because hospitals and even our own government would rather save a few pennies buying from China, ” said Lloyd Armbrust, president of the American Mask Manufacturers Association. Its membership includes just eight companies that are still producing masks, down from 51 a year ago. He said 17 of the businesses have shut down.

Some experts say the particular C. D. C. ’s hands-off approach to elastomeric respirators is unintentionally encouraging a return to the nation’s reliance upon disposable masks made overseas. Dr . Eric Feigl-Ding, a good epidemiologist who heads the Covid-19 task force at the World Health Network, criticized federal officials for inaction despite compelling evidence that elastomerics provide the highest level of protection against aerosolized viruses. “At a certain point, you need to act on the existing science, and the failure to do otherwise is a dereliction of responsibility, ” he said.

To be clear, federal government health experts back the use elastomerics but say they are awaiting additional study results before offering full-throated support for their widespread adoption simply by medical personnel. Emily Haas, a scientist at the C. D. C. ’s National Institute for Occupational Safety and Health, or NIOSH, said researchers were still grappling with the need to regularly disinfect them and complaints about muffled communication, though a few newer models make it easier for wearers to be heard.

The bigger challenge, she says, is convincing hospitals and group purchasing organizations to embrace the particular masks given the abundance of N95s, which offer comparable protection during routine medical care and can be thrown away after each use.

“There’s been so much research in the last 10 years that has really supported elastomerics, so in some ways the issue right now is cultural, ” Dr . Haas said. “No one likes change, and introducing a whole new system of respiratory protection can be a heavy lift. ”

Experts say such obstacles could be overcome through more muscular federal leadership. Dr . Tom Frieden, who led an unsuccessful effort to fill the Strategic National Stockpile with elastomerics when he was Chemical. D. C. director in 2009, said the advantages of providing them to frontline medical workers were clear, especially given the nation’s ruinous overreliance on single-use masks. He stated health authorities could promote elastomerics by highlighting their cost savings for hospitals and the environmental benefits of a reusable mask to help reduce the tsunami of N95s that end up in landfills. “To me, it’s a puzzle why these people haven’t become more widespread, ” Dr . Frieden said.

Providing an elastomeric respirator to each of the nation’s 18 million health care employees would cost roughly $275 million, according to Nicolas Smit, an expert on elastomerics plus executive director of the American Mask Manufacturers Association. By comparison, he noted that the federal government spent $413 million on a disastrous work to decontaminate N95 masks so they could be safely reused.

Cooper Neill for The New York Times

James C. Chang, an industrial hygienist, has long been a fan of elastomerics. In 2018, he helped to produce a report on them for the National Academies of Sciences, Engineering and Medicine, and after the short-lived swine flu pandemic of 2009, he persuaded his employer, the University of Maryland Medical Center, to purchase 1, 500 masks. The decision was based in part on research that will predicted a respiratory pandemic lasting more than a few weeks would lead to catastrophic supply-chain shortages.

“When you ran the numbers, it was pretty clear we’d burn through a six- or seven-digit cache of disposables pretty quickly, ” he mentioned. “It’s just not feasible for any hospital to stock that many masks. ”

Initially he had a handful of issues — that their “Darth Vader” look would frighten patients or that disinfecting them would be burdensome. But those fears quickly faded in early 2020 as hospitals across the country scrambled to find N95s, and the C. D. D. issued guidelines saying N95s could be reused up to five times — guidance that evoked widespread skepticism among health professionals.

To deal with the need to disinfect the masks, he set up a system that allowed workers to drop them off right after each shift so they might be cleaned before being made available to others.

“It was a real success story on our end because our staff had respirators to wear and they felt more reassured wearing elastomerics than wearing N95s, ” Mr. Chang said.

One of the only other hospital systems in the country to adopt the masks on a large scale was Allegheny Health Network of Western Pennsylvania, which early in the outbreak, distributed more than 8, 000 respirators at its 14 hospitals. The decision to do so stemmed from a coincidence of geography: Allegheny’s headquarters in Pittsburgh was not far from the manufacturing plant of MSA Safety, the century-old company that got its start producing coal miner protective gear with help from Thomas Edison.

Prompted by an appeal from hospital administrators, MSA began sending over the industrial-grade masks but they quickly ran into a problem. The protruding filters just screened inhaled air, which meant that exhaled air from an infected wearer could pose a potential wellness risk to those nearby, according to Dr . Zane Frund, executive director for materials and chemicals research at MSA Safety.

The solution was not exactly rocket technology: Product designers simply removed the masks’ exhalation valve, and NIOSH in late 2020 approved the new models . A subsequent design tweak added a mechanical voice amplifier to help ease communication.

Dr . Sricharan Chalikonda, Allegheny’s chief medical operations officer, said he was surprised by just how popular they will became among the 2, 500 medical personnel who had been outfitted to wear them — a process aimed at ensuring air would not evade the mask’s tight face seal.

Kirsten Luce for The New York Times

According to a paper he published in the Journal of the American College of Surgeons, none of the employees went back in order to wearing N95s. The cost benefit of relying almost entirely on elastomerics became irrefutable: Outfitting the workers was one-tenth as expensive than supplying them with disposable N95s. A separate study found that after one year, the filters had been still 99 percent effective.

“Elastomerics for us really were a game changer, ” Doctor Chalikonda said. “When I think of all the millions of dollars wasted upon N95s and then trying to reuse them makes you realize how much elastomerics are a missed opportunity. ”

Federal health officials say these are moving as fast as possible to produce stronger guidance on elastomerics. Maryann D’Alessandro, director of the National Personal Protective Technology Laboratory, said scientists were reviewing feedback from a study that distributed nearly 100, 000 respirators to hospitals, nursing homes plus first-responders across the country. “If we can get a tool kit together to serve as a guide regarding organizations and educate the users, we hope it can help move the particular needle, ” she stated.

Many face masks entrepreneurs are not likely to last that long. Max Bock-Aronson, the co-founder of Breathe99, which makes an elastomeric respirator that Time magazine included on its 2020 list of best inventions, has been winding down operations in the company’s Minnesota plant.

He blamed the particular slump in sales on Covid fatigue and waning public interest in protective gear. The company’s fortunes, this individual added, were doomed early on by the C. D. G. ’s mask guidance, which usually prompted Amazon, Google and Facebook to limit or bar the sale associated with medical-grade masks to consumers, even as P. P. E. imports once again began flooding the United States.

“The whole industry has been gutted, ” said Mr. Bock-Aronson. “Every time there’s a new variant, we get a small bump in sales, but I haven’t taken the nickel out of the company since last May, ”

For now, he is focused on finding a buyer for his company while selling off his inventory online. The particular masks cost $59 and can be sheathed in washable covers that come in eight colors, among them crimson, linen and royal blue.

All sales, the website points out apologetically, are final.


Leave a Reply

Your email address will not be published. Required fields are marked *